Section V. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)

ARMY TM5-6115-612-12 NAVY AG-320B0-0MM-000 Section V. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) 4-9. GENERAL. To ensure that the generator set is ready for operation at all times, It must be Inspected systematically so defects may be discovered and corrected before they result In serious damage or failure Defects discovered during operation of the unit, such as minor oil leaks or burned out lights, shall be noted for future correction Stop operation immediately If a deficiency is noted, such as abnormal noise, excessive vibration, fuel leaks, or smoke, that would Indicate equipment damage. All deficiencies shall be recorded on the applicable form together with the corrective action taken Air Force users shall refer to the applicable Inspection manuals and work card sets in TO 35C2-3 Series for periodic requirements Marine Corps users shall refer to the current Issue of TM 11275 15 1 Table 4 1 provides a list of preventive maintenance checks ;and services (PMCS) that shall be performed by organizational maintenance personnel at weekly monthly and semi annual Intervals The Item numbers are listed consecutively and Indicate the sequence of performance Table 4-1 Preventive Maintenance Checks and Services W - Weekly (40 hours) Total M/’H: 1 0 Interval M - Monthly (100 hours) Total M/H: 7 1 S - Semiannual (500 hours) Total M/H: 4 3 Organization Work W M S Inspection procedures M H 1 BATTERY AND CABLE Service battery In accordance with paragraph 4 27 Clean cable connections In accordance with paragraph 4-26b 0 5 2 LUBRICATION LINES AND FITTINGS Inspect lubrication lines and fittings In accordance with paragraph 4-53a 0 2 3 GEARBOX ASSEMBLY AND GEARBOX HOUSING Inspect gearbox assembly and gearbox housing in accordance with paragraphs 4-60c and 4-62c 0 1 4 COMBUSTOR HOUSING AND COMPRESSOR INLET HIOUSING Inspect combustor housing and compressor inlet housing in accordance with paragraphs 4 58c and 4 59c 0 1 5 INDICATOR LIGHTS AND SOCKETS Test indicator lights and sockets in accordance with paragraph 4-73a () 1 416 Change 6