Chapter 1. INTRODUCTION

TM 5-6115-400-35

CHAPTER 1

INTRODUCTION

Section I. GENERAL

1. Scope

c. Report

all

equipment

improvements

recommendations as prescribed by TM 38-750.

a. These instructions are published for the use of

direct and general support and depot maintenance

2. Record and Report Forms

personnel maintaining the Military Standard Model SF-

a. DA Form 2258 (Depreservation Guide of

200-MC/CIED (Allis-Chalmers Model 25000-4444650)

Engineer Equipment).

Generator Set.

They provide information on the

b. For other record and report forms applicable to

maintenance of the equipment, which is beyond the

direct and general support and depot maintenance, refer

scope of the tools, equipment, personnel, or supplies

to TM 38-750.

normally available to using organizations.

Note. Applicable forms, excluding

b. Report

errors,

omissions,

and

standard Form 46 (United States

recommendations for improving this publication by the

Government

Motor

Vehicle

individual user is encouraged. Reports should be

Operator's Identification Card) which

submitted on DA Form 2028 (Recommended Changes

is carried by the operator, shall be

to DA Publications) and forwarded direct to the

kept in a canvas bag mounted on the

Commanding General, U. S. Army Mobility Equipment

equipment.

Command, ATTN: AMSME-MPP, 4300 Goodfellow

Blvd., St. Louis, Mo. 63120.

Section II. DESCRIPTION AND DATA

601/347

3. Description

Phase .................................3

A general description of 6 generator set, the location

Power factor .......................0.8

and description of the identification and instruction

Frequency ..........................60/50 cycles

plates, and information on the differences in models are

Cooling ..............................Fan

contained in the Operator and Organizational

Lubrication .........................Sealed bearing

Maintenance Manual. The repair and maintenance

Duty classification ..............Continuous

instructions are described in appropriate sections of this

Degree of enclosure ...........Full, dripproof, guarded

manual.

Drive ..................................Direct

Type ...................................Synchronous

4. Tabulated Data

Temperature rise ................185° (85° )

a. General.

This paragraph contains all the

c. Exciter Classification and Rating.

overhaul data pertinent to direct and general support

and depot maintenance personnel. A wiring diagram

Type ...................................Static

(fig. 1) is also included.

Rating ................................At full load, 2.1 kw/60;

b. Generator Classification and Rating.

2.5 kw/50

Voltage ..............................151 volts D.C. (direct

Rating ................................200 kw (kilowatts)

current) 58 v/60 cps;

Voltage ..............................120/208; 240/416 volts

65 v/60 cycles

Amperes ............................694/580; 347/290At 60

Amperes ............................35 a/60; 39 a/60

cycles 1200/694;