LUBRICATION ORDER - GENERATOR SET, DIESEL ENGINE DRIVEN SKID MTD., 100 KW (CONT)

The time specified is the time required to

erform all services at the particular interval

On-condition or hard time).

*TOTAL TASK-HR

INTERVAL

TASK-HR

INTERVAL

50H or 60D

0.1

0.6

1000

1.0

0.6

100

-KEY-

EXPECTED TEMPERATURES

ABOVE +32 F

+40 P

-10 F

TO -65-F

INTERVALS

CAPACITY

LUBRICANTS

(ABOVE 0 C)

(+5 C TO

-23 C) (-18 C TO -50'C

OE/HDO

LUBRICATING OIL,

Intervals

(MIL-L-2104D)

Engine

OE/HDO 15-40

given are

Engine Crankcase

OEA

in hours of

29 qts (27.5L)

with Filters

normal

OE/HDO 30

OE/HDO 10

Oil Can points

operation

LUBRICATING OIL,

(MIL-H-46167) Engine, Subzero

OHA

HYDRAULIC FLUID

8 qts (7.6L)

OHA

(MIL-H-56068) Hydraulic Tank,

Filters and Lines

NOTES:

A sample of the oil shall

CRANKCASE OIL.

FOR OPERATION OF EQUIPMENT IN PROTRACTED

be sent to an AOAP laboratory for analysis at

COLO

TEMPERATURES BELOW -10°F (-23'C). Remove

an interval of 50 hours or 60 days.

Refer to

lubricants

prescribed in

the

for

key

TB 43-0210 for sampling requirements.

temperatures above -1O'F (-23'C). Clean parts

with

drycleaning SOLVENT (SD), type II or

When AOAP laboratory

support is not avail-

equivalent.

Lubricate

with

lubricants

able, drain and refill

crankcase oil at 300

specified in the key for temperatures O'F to

hours or 6 months.

-65°F.

Copy

this

Lubrication

Order

will

remain

OIL CAN POINTS.

Every 100 hours

lubricate

with the equipment at all times; instructions

iinges,

latches,

control

linkages,

and all

contained herein are mandatory.

exposed adjusting threads with OE-HDO.

Every 300 hours remove

ENGINE OIL FILTER.

filter element, clean housing, install new ele-

By Order of the Secretary of the Army:

ment,

fill

crankcase,

operate

engine

for

minutes, check for leaks, check crankcase oil

Oil filter

CARL E. VUONO

level, and bring to FULL mark.

replacement interval shall aline with on-condi-

General, United States Army

time o i l

change

hard

Chief of Staff

tion

AOAP or

official:

requirements.

See notes 5 and 6.

R. L. DILWORTH

SET DIFFERENCES.

Used

precise

generator

Brigadier General. United States Army

sets only.

7he Adjutant General

DISTRIBUTION:

To be distributed in accordance with DA Form

12-25A, Operator and Unit Maintenance require-

ments for Generator Set, Diesel Driven, Tacti-

cal, 120/208V, 240/216V, 50/60HZ, 3 PH, 4 Wire

(100KW: MEP-007A,

MEP-106A; 400KW: MEP-116A).

u.s. GOVERNMENT

LO5 -8115-457-12