TM  55-1520-240-23-9 11-13 REPAIR  FINISH OF BELLCRANK  AND  ARMS 11-13 INITIAL  SETUP Applicable  Configurations: All Tools: Protective  Clothing Heat  Gun Beaker,  50  cc’s Container,  2  Quart Thermometer Rubber Apron Materials: Cloths  (E112) Cloths  (E120) Tape  (E388) Abrasive  Paper (E9) Calcium  Sulphate  (E91) Sodium  Hydroxide  (E358) Chromic  Acid  (E114) Nitric  Acid  (E22) Thinner  (E415) Epoxy Primer  (E293) Epoxy Topcoat  (E425) Alodine  (E65) Epoxy Primer  (E292.1) Naphtha  (E245) Cleaning  Compound  (E119) Gloves  (E184.1) Personnel  Required: Aircraft  Structural  Repairer Inspector Equipment  Condition: As  Required General  Safety Instructions: Sodium  hydroxide  (E358),  chromic acid  (E114),  and  nitric acid  (E22)  are extremely toxic.  They can  irritate  skin and  cause  burns.  Avoid  inhaling.  Use only with  adequate  ventilation.  Avoid contact  with  skin,  eyes,  or  clothing. In  case  of  contact,  immediately  flush skin  or  eyes  with  water  for at  least 15  minutes.   Get  medical  attention for eyes. Thinner (E415) and  epoxy  primers (E293  and  E292.1)  are  flammable and  toxic.   They  can  irritate  skin  and cause  burns.  Use  only with  adequate ventilation,  away  from  heat  or  open flame.   Avoid  contact  with  skin,  eyes, or  clothing.   In  case  of  contact, immediately  flush  skin  or eyes  with water  for  at  least 15 minutes.   Get medical  attention  for eyes. Epoxy  topcoat  (E425)  is  extremely toxic.   It can  irritate  skin  and  cause burns.   Avoid  inhaling.  Use  only with adequate  ventilation.   Avoid  contact with  skin,  eyes,  or clothing.   In  case of  contact,  immediately  flush  skin or  eyes  with  water  for at  least  15 minutes.   Get medical  attention  for eyes. Alodine  (E65)  is an  oxidizer.  Discard cloths  which  contain  this  material  in  a separate  container.  If discarded  with cloths  contaminated  with  acetone, MEK,  or  other  organic  solvents, combustion  can  result.   In  case  of contact, immediately flush skin  or eyes with  water for  at  least  15 minutes. Get medical  attention  for eyes. Naphtha  (E245)  is  flammable  and toxic.   It can  irritate  skin  and  cause burns.   Use  only  with  adequate ventilation,  away  from  heat  or  open flame.   Avoid  contact  with  skin,  eyes, or  clothing.   In  case  of  contact, immediately  flush  skin  or eyes  with water  for  at  least 15 minutes.   Get medical  attention  for eyes. 11-50