Chapter 7: DIFFERENCE DATA

TM 11-6625-2631-14

CHAPTER 7

DIFFERENCE DATA

D I F F E R E N C E DATA SHEET

TS-2530A/UR

Test SET, BATTERY

(NSN 6625-00-238-0223)

THE INFORMATION CONTAINED IN CHAPTERS 1 THROUGH 6 AND APPENDIXES B AND C OF THIS

TECHNICAL MANUAL ARE APPLICABLE TO THIS MODEL EXCEPT FOR THE DIFFERENCES

CITED IN THIS DIFFERENCE DATA SHEET

cable red lead between red lead termination cap and

7 - 1 . Introduction

PRC-63 and URT-21 positive (+) connector on the

Test Set, Battery TS-2530A/UR (fig. 7-1) is the same

front panel. Check continuity of test cable black lead

as the TS-2530/UR except that the TS-2530A/UR does

between black lead termination cap and PRC-63 and

not require the use of the MX-8801/PRC-80 for testing

URT-21 negative (-) connector on the front panel.

battery used in the AN/PRC-90. For the Ts-2530A/UR

the URC-10 battery test connector cable has been

7-5. Functioning of Equipment

removed and replaced with a hard wired-in test cable

Same as far TS-2530/UR except fur changes in block

for testing Battery BA-1568/U used in the

diagram and schematic diagram as shown in figures

AN/PRC-90. The red lead (postive) and black lead

7-2 and 7-8.

(negative) of this cable are terminated with plastic

7-6. General Support Maintenance

molded cups which are used to connect the battery

Same as for TS-2530/UR except for the following

being tested.

a. Test able of TS-2530A/UR is used in place of

7-2. Service Upon Receipt and Installation

MX-8801/PRC-90 for operational test of PRC-90 bat-

Same as for TS-2530/UR, except test cable is used in

tery.

place of MX-8801/PRC-90.

b. When replacing TS-2530/UR test cable, use grom-

met part No. A1-18-0257-3 and test cable part No. A3-

7-3. Operating Instructions

06-0511.

Same as for TS-2530/UR except cable is used in

place of MX-8801/PRC-90. Also the following updated

7 - 7 . Appendix B. Maintenance Allocation

battery test information applies to both modles when

Same as for TS-2530/UR except TS-2530A/UR test ca-

testing Battery BA-1568/U:

ble is used in place of MX-8801/PRC-90.

a.The PRC-90 battery data card is not to be used

7-8. Appendix C. Organizational, Direct

Test meter reading given in b below is used to deter-

Support, and General

mine if battery tested is considered acceptable far

Support Maintenance

further use.

Repair Parts and Spe-

b. Meter reading below 0.74 indicated a weak

c i a l Tools List

BA-1568/U battery and these batteries should be re-

Same as for TS-2530/UR except that TS-2530A/UR

jected. Meter reading of 0.74 and above indicates an

used grommet part No. A1-18-0257-3 and test cable

acceptable BA-1568/U battery.

part No. A3-06-0511.

7-4.

Organizational

Maintenance

lnstruc-

tions.

7-9. Illustrations

The following figures 7-1, 7-2, and 7-8 apply to

Same as for TS-2530/UR except for continuity check

TS-2530A/UR only:

of TS2530A/UR test cable. Checck continuity of test

7-1

Change 1