WARNING

TM 5-4110-234-14

TO 40R7-5-7-1

WARNING

input when installing or operating

WARNING

this equipment.

DANGEROUS CHEMICAL

Clean parts in a well-ventilated

Whenever the nature of the

is used in this equipment

area. Avoid inhalation of solvent

operation permits, keep one hand

DEATH

fumes and prolonged exposure of

away from the equipment to reduce

or severe damage may result if

skin to cleaning solvent. Wash

the hazard of current flowing

personnel fail to observe safety

exposed skin thoroughly.

through vital organs of the body.

precautions. Use great care to

Dry cleaning solvent (Fed. Spec.

Do not operate the equipment

avoid contact with liquid refrigerant

PD-680) used to clean parts is

without all grilles, guards, louvers,

or refrigerant gas being discharged

potentially dangerous to personnel

and covers in place and tightly

under pressure.

Sudden and

and property.

secured.

irreversible tissue damage can

Do not use near open flame or

result from freezing. Wear thermal

excessive heat. Flash point of

Warning: Do not be misled by

protective gloves and a face

solvent is 100OF to 138°F (38°C to

the

term

"low

voltage."

protector or goggles

in any

50°C).

Potentials as low as 50 volts

situation where skin eye contact is

Wear eye protection when blowing

may cause death under adverse

possible.

solvent from parts. Air pressure

conditions.

Prevent contact of refrigerant gas

should not exceed 30 psig (2.1

with flame or hot surfaces. Heat

kg/cm2).

Model F10000RG-2

causes the refrigerant to break

WARNING

down and form carbonyl chloride

Protect Against Moving Parts Do

DO NOT fill fuel tank while engine

(phosgene), a highly toxic and

not wear loose clothing in the

is running.

corrosive gas.

vicinity of moving parts, such as

DO NOT smoke or use an open

WARNING

shafts, flywheels, fans, belts, etc.

flame in the vicinity of the engine or

Keep your hands away from

REFRIGERANT

UNDER

fuel tank.

Internal combustion

moving parts.

Do not operate

PRESSURE is used in the

engine fuels are highly flammable.

without protective guards and

operation of this equipment.

Model F10000RG-2

POISON

screens securely in place. Model

DEATH

CAUSES

SEVERE

BURNS

F10000R-6

or severe injury may result if you

ELECTROLYTE (ACID) BATTERY

WARNING

fail to observe safety precautions.

FLUID CONTAINS SULFURIC

HIGH VOLTAGE

Never use a heating torch on any

ACID AVOID CONTACT WITH

is used in the operation of this

part that contains Refrigerant R-12.

SKIN, EYES, OR CLOTHING.

equipment DEATH ON CONTACT

Do not let liquid refrigerant touch

PREVENT

ACCIDENTS,

may result if personnel fail to

you, and do not inhale refrigerant

NEUTRALIZE EXCESS

ACID

observe safety precautions. Never

gas.

WITH BAKING SODA AND RINSE

work on electrical equipment

WARNING

EMPTY

CONTAINER

WITH

unless there is another person

Compressed air used for cleaning

WATER.

nearby who is familiar with the

purposes will not exceed 30 PSI

ANTI DOTE:

operation and hazards of the

(2.1 kg/cm2).

EXTERNAL-FLUSH

WITH

equipment and who is competent

WARNING

WATER.

in administering first aid. When the

Acetone and methyl-ethyl ketone

INTERNAL-DRINK

LARGE

technician is aided by operators,

(MEK) are flammable, and their

QUANTITIES OF WATER OR

he must warn them about

vapors

can

explosive.

MILK.

dangerous areas.

Repeated or prolonged skin

WITH

MILK

Whenever possible, the input

contact or inhalation of vapors can

MAGNESIA, BEATEN EGGS, OR

power supply to the equipment

be toxic. Use a well-ventilated

VEGETABLE

OIL.

CALL

must be shut off before beginning

area, wear gloves, and keep away

PHYSICIAN IMMEDIATELY.

work on the equipment.

Take

from sparks or flame.

particular care to ground every

EYES-FLUSH WITH WATER FOR

capacitor likely to hold a dangerous

15 MINUTES AND GET PROMPT

potential. When working inside the

MEDICAL ATTENTION.

equipment, after the power has

been turned off, always ground

KEEP OUT

REACH

every part before touching it.

CHILDREN.

Be careful not to contact high

voltage connections of 208 volts ac

W-1

TM5-4110-234-14

TO 40R7-5-7-1